Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 1• Do not store or use gasoline or other fl am-mable vapors and liquids in the vici
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/0810Kit contents: Replacement orifi ce; replacement pilot injector; valve regulator; co
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 11A BCFigure 6.5C. Valve Regulator ReplacementRemove upper and lower back shield.
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/0812If the pressure is not suffi cient, ensure: • The piping used is large enough. •
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 13Fire hazard. Do NOT change the valve settings.• This valve has been preset at th
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/0814C. Standing Pilot Ignition System WiringThis appliance DOES NOT require 110 VAC s
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 15Figure 7.2ROCKER SWITCH / WALL THERMOSTAT / REMOTEVARIABLE REGULATORPILOT ADJUSTM
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/0816C. Door Crown InstallationOpen lower access panel. Pull out and unhook the two s
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 17D. Grille InstallationRemove the door of appliance. Remove the four screws (two
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/0818F. Brick InstallationFigure 8.9 Figure 8.10 Figure 8.11 Figure 8.12Figure 8.1
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 19G. Positioning the LogsWhile still breakable, the logs do not become fragile unt
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/082APPROVED FOR CANADA AND USA TO:ANSI Z21.88b-2003 / CSA 2.33b-2003 Vented Gas Firepl
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/0820H. Mineral Wool I. Blower InstallationIncluded in kit: Blower.Tools required: Pow
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 21Figure 8.26 Figure 8.27Installation is the reverse of removal.Figure 8.28 Blowe
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/0822Figure 8.29J. Air Shutter AdjustmentThe air shutter is used to fine-tune the flame
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 23A. Before Lighting ApplianceRead this entire manual prior to using the appliance.
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/0824B. Lighting Appliance1. Set the thermostat to lowest setting. 2. Turn off all el
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 25Initial Break-in ProcedureWhen you light the appliance, you may notice that it pr
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/0826A. Standing Pilot Ignition System10 10 Troubleshooting With proper installation,
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 27Troubleshooting (continued)Symptom Possible Cause Corrective Action3. Continued c
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/0828A. Glass ReplacementGlass can be replaced either as three separate pieces, or as a
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 29Inspect Maintenance TasksDoors 1. Inspect for scratches, dents or other damage a
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 3Table of Contents1 Listing and Code Approvals A. Appliance Certifi cation . . . .
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/0830MINIMUM FIREBOX OPENINGHeight: Width: Depth:Front Rear Front Rear Top BottomInche
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 31B. Vent Components List Venting System Components DescriptionHHT Component #LINK
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/0832R213141567810121191345Service Parts DiagramColumbia Bay InsertCOLBAY-INSBeginning
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 33COLBAY-INSIMPORTANT: THIS IS DATED INFORMATION. When requesting service or replac
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/083421367810121191345Bottom Firebox AssemblyRValve Assembly DiagramColumbia Bay Insert
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 35D. Limited Lifetime WarrantyHearth & Home Technologies LIMITED WARRANTYHeart
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/0836D. Limited Lifetime Warranty (continued)• This limited warranty does not extend
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 37Quadra-Fire, a brand of Hearth & Home Technologies Inc. 20802 Kensington Boul
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/084Manufactured Home or Mobile Home installation may occur only after the home is site
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 5A. Design and Installation ConsiderationsQuadra-Fire direct vent gas appliances a
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/086Figure 3.1 To 8 in. (203 mm ) Deep mantel: 14 in. (356 mm) From top of insertABDC
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 7Fire Risk.Asphyxiation Risk.• Terminations MUST meet minimum clearances.• Exhaus
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/088TERMINATION CAPADAPTERFLEX PIPETRANSITION ASSEMBLYSHIPPING BRACKETS ATTACHED TO REA
Quadra-Fire • Columbia Bay Insert • 7002-109 Rev. H • 10/08 9INSULATIONV=10 FT. (3 M) MINIMUM40 FT. (12 M) MAXIMUMTERMINATION CAPADAPTORINLET A
Kommentare zu diesen Handbüchern