Quadra-Fire 7100FP Bedienungshandbuch

R EPA CERTIFIED WOODBURNING FIREPLACEO-T LTested and Listed byPortlandOregon USAOMNI-Test Laboratories, Inc.CUSModel(s):7100FP-BK-B7100FP-GD-B7100FP-N

ACC Override ControlLeft - Close 2. ACC OverrideTheleverlocatedtotherightofthecombustionaircon-trolistheACCOVERRIDEandmaybeusedto

Asourceof air(oxygen)isrequiredin orderforcom-bustiontotakeplace.Turningtheoutsideairhandleclockwiseopenstheout-sideairinlet;t

6. Convection Fan OperationThereplaceis equipped with a temperature-senitivesnap disc that willturnthe convection fan onand offaut

Softwoods Hardwoods• DouglasFir • Oak• Pine • Maple• Spruce • Apple• Cedar • Birch• Poplar• Aspen• AlderWARNING! Risk of Fire!• DO

D. First FireBeforelightingyourrstreinthereplace,makecertainthat:• thebafeandceramicblanketarecorrectlypositioned,restingagain

F. Heat ManagementFormaximumoperatingefciencywiththelowestemis-sions,followtheseoperatingprocedures:• Regardless of desired heat out

4 Maintenance and Service WARNING! Hot Surfaces!GlassandothersurfacesarehotduringoperationANDcooldown. DO NOTcleanreplaceuntilitisc

WARNING! Risk of Fire! IgnitedcreosoteisextremelyHOT. Prevent creosote buildup.2. Creosote (Chimney) Cleaning Frequency: Asneeded;atleastann

6. Door Gasket Frequency: Seasonally By: Homeowner • Opendoor,placehalfadollarbillinsideandclosethedoor.• Attempttopullthebillout.•

B. Replacement Maintenance1. Glass Replacement• Ensurethatthereisoutandthereplaceiscooltothetouch.• Protectatableorcountertopw

Table of Contents Safety Alert Key:• DANGER! Indicatesahazardoussituationwhich,ifnotavoidedwillresultindeathorseriousinjury.• WARNING

455555555355555222224555311555555 5 5 5511422222455535553Left SideRight SideBackFloor1-1/4" 3-1/4" 9.0" 1 3 Firebrick ReplacementThe

4. Bafe Removal and InstallationFigure 4.5 Removing Bafe Protection ChannelFigure 4.6 Removing Manifold TubeFigure 4.7 Removing Bafe (shownwit

Unplug wire harness before removing fanRemove nut and lift out fan• Removingthefan - Unplugthewireharness.- Liftfanfromlocatingpinsandr

Remove 2 screws Figure 4.14 Disconnect Air Chamber CoverMove arm left Be careful not to drop Linkage Arm down into fireplace - Removetwoscrewsf

• After re-installing the timer assembly through thereboxaccessdoor,re-attachthetimerassemblytotheairchambercoverusingaPhillips

12345345678910Figure 4.24 Exploded View of Entire Assembly for Point of Refer-ence onlyItem Description Qty1 DoorLinkage 12 LinkageControlArm 13 B

5 Troubleshooting Ifsmokespillageoccursfromareplaceopeningwhenthedoorisopen,thereiseitheraleakageintheue,ablockageintheue

Another appliance in home also exhaustingair (furnace, fan, dryer, etc.)?Air register fromfurnace nearfireplace?Doors openingand closing?Window closed

B. Troubleshooting TableFire is dicult to start • Refer to secon 4.C. Lighng Instrucons• Open air controls• Establish dra: Hold a lighted, rolled

6 Reference Materials A. Service PartsService Parts7100 FPBeginning Manufacturing Date: Mar 2005 Ending Manufacturing Date: ActiveWoodburning Firepl

Readthismanualbeforeinstallingoroperatingthisreplace.Pleaseretainthisowner’smanualforfuturereferences.A. CongratulationsCongratulation

Service Parts7100 FPBeginning Manufacturing Date: Mar 2005 Ending Manufacturing Date: ActiveIMPORTANT:THISISDATEDINFORMATION.Partsmustbeordere

Service Parts7100 FPBeginning Manufacturing Date: Mar 2005 Ending Manufacturing Date: Active#13 Door, Glass and Door Handle Assembly13.913.713.1013.31

Service Parts7100 FPBeginning Manufacturing Date: Mar 2005 Ending Manufacturing Date: ActiveIMPORTANT: THIS IS DATED INFORMATION. Parts must be

Service Parts7100 FPBeginning Manufacturing Date: Mar 2005 Ending Manufacturing Date: ActiveIMPORTANT: THIS IS DATED INFORMATION. Parts must be

This page intentionally left blank.34Quadra-Fire • 7100 FP Owner’s Manual • 433-3600 • Rev G • 06/25/14

This page intentionally left blank.35Quadra-Fire • 7100 FP Owner’s Manual • 433-3600 • Rev G • 06/25/14

B. Contact Information– NOTES –Printed in U.S.A. - Copyright 2012DO NOT DISCARD THIS MANUALCAUTION• Leave this manual with party responsible for

4021-645F02-18-13 Page1of2Hearth & Home TechnologiesLIMITED LIFETIME WARRANTYHearth&HomeTechnologies,onbehalfofitshearthbrands

4021-645F02-18-13 Page2of2WARRANTY CONDITIONS:• ThiswarrantyonlycoversHHTappliancesthatarepurchasedthroughanHHTauthorizeddealeror

2 Product Specic Information A. Fireplace CerticationWarning! Risk of Fire! For use with solid wood fuel only.Otherfuelsmayoverreandgeneratepo

A. Fireplace SafetyMostproblemsarecausedbyimproperinstallationandop-erationofthereplace.Toprovidereasonableresafety,thefollowing

5. Chimney FireIntheeventofachimneyre• Havethechimneyandadjacentstructureinspectedbyqualiedprofessionals.Hearth&HomeTechnol

B. General Operating PartsWARNING! DO NOT operatereplacebeforereadingandunderstandingoperatinginstructions.Failuretooperatere-placeacc