Quadra-Fire Direct Room CASTILE-GAS-CWL Bedienungshandbuch PDF herunterladen

www.quadraﬁre.com

September 1, 2008

CASTILE GAS STOVE

DIRECT VENT ROOM HEATER

Owner’s Manual

Installation and Operation

Model:

7023-111E

CASTILE-GAS-MBK

CASTILE-GAS-PMH

CASTILE-GAS-CSB

CASTILE-GAS-CWL

O-T L

Tested and

Listed by

Portland

Oregon USA

OMNI-Test Laboratories, Inc.

DO NOT DISCARD THIS MANUAL

CAUTION

• Important operating and

maintenance instructions

included.

• Leave this manual with

party responsible for use

and operation.

• Read, understand and

follow these instructions

for safe installation and

operation.

• Do not store or use gasoline or other ﬂam-

mable vapors and liquids in the vicinity of this

or any other appliance.

• What to do if you smell gas

- Do not try to light any appliance.

Do not touch any electrical switch. Do not

use any phone in your building.

- Immediately call your gas supplier from a

neighbor’s phone. Follow the gas supplier’s

instructions.

- If you cannot reach your gas supplier, call

the ﬁre department.

• Installation and service must be performed

by a qualiﬁed installer, service agency, or the

gas supplier.

WARNING: If the information in these

instructions is not followed exactly, a ﬁre

or explosion may result causing property

damage, personal injury, or death.

This appliance may be installed as an OEM installation in manufactured

home (USA only) or mobile home and must be installed in accordance with

the manufacturer's instructions and the manufactured home construction and

safety standard, Title 24 CFR, Part 3280 or Standard for Installation in Mobile

Homes, CAN/CSA Z240MH.

This appliance is only for use with the type(s) of gas indicated on the rating plate.

Installation and service of this appliance should be

performed by qualiﬁed personnel. Hearth & Home

Technologies suggests NFI certiﬁed or factory-trained

professionals, or technicians supervised by an NFI

certiﬁed professional.

DO NOT

DISCARD

In the Commonwealth of Massachusetts:

• installation must be performed by a licensed plumber or gas

ﬁtter.

See Table of Contents for additional Commonwealth of Mas-

sachusetts requirements.

HOT SURFACES!

Glass and other surfaces are

hot during operation AND

cool down.

WARNING

Hot glass will cause burns.

• Do not touch glass until it is cooled

• NEVER allow children to touch glass

• Keep children away

• CAREFULLY SUPERVISE children in the same room

as appliance

• Alert children and adults to hazards of high

temperatures

High temperatures may ignite clothing or other

ﬂammable materials.

• Keep clothing, furniture, draperies and other

combustibles away.

1 2 3 4 5 6 ... 55 56

Inhaltsverzeichnis

Seite 1 - CASTILE GAS STOVE

www.quadraﬁre.com September 1, 2008R CASTILE GAS STOVEDIRECT VENT ROOM HEATER Owner’s ManualInstallation and OperationModel: 702

Seite 2 - Test Lab & Report No

Page 10September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111E5Vent InformationA. Venting ComponentsB. Use of ElbowsIn order to comply with appl

Seite 3 - - TABLE OF CONTENTS

September 1, 2008Page 11Quadra-Fire · Castile Gas Stove · 7023-111ED. How to Use the Vent Graph E. Venting Guidelines1. Measure the vertical distanc

Seite 4 - ּCAN/CBA 2.17-M91

Page 12September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111EF. Horizontal Termination45° Elbow 1 in. (25mm) Clearance from appliance corner t

Seite 5 - Massachusetts

September 1, 2008Page 13Quadra-Fire · Castile Gas Stove · 7023-111EStep 3. For installations using a round support box/wall thimble (check pipe manuf

Seite 6 - Getting Started

Page 14September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111EStep 5. Place the wall thimble cover over the pipe assembly and slide the applian

Seite 7 - B. Clearances

September 1, 2008Page 15Quadra-Fire · Castile Gas Stove · 7023-111EStep 1. Check the installation instructions for required 1 in. (25mm) clearances (

Seite 8 - Termination Locations

Page 16September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111EPlumber’s Tapeconnected to Wall StrapWall StrapTwo 45˚ ElbowsFigure 5.12 Step 4. A

Seite 9 - Figure 4.4

September 1, 2008Page 17Quadra-Fire · Castile Gas Stove · 7023-111EStep 8.Slip the storm collar over the pipe, and push it down to the top of the fla

Seite 10 - Figure 5.1

Page 18September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111E2. Cathedral CeilingLevelCathedral Ceiling Support Box2 in. (51mm) Min. belowfinis

Seite 11 - Figure 5.2

September 1, 2008Page 19Quadra-Fire · Castile Gas Stove · 7023-111E3. Class A Metal ChimneyFigure 5.20 Termination CapExistingMetal ChimneySystemTop

Seite 12 - Figure 5.4

Page 2Quadra-Fire · Castile Gas Stove · 7023-111E · September 1, 2008and Welcome to the Quadra-Fire Family!Hearth & Home Technologies welcomes y

Seite 13 - Wall Thimble

Page 20September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111EChimney LinerTermination CapCo-Axial to Co-Linear Connector30 ft. (9m) of 3 in. (7

Seite 14 - Figure 5.9

September 1, 2008Page 21Quadra-Fire · Castile Gas Stove · 7023-111E10 in. x 10 in. (254mm x 254mm) framed opening in wallStudwallMasonryChimneyRetro

Seite 15 - Figure 5.10

Page 22September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111EHigh Wind Termination CapTop Adaptor(3) Sheet Metal ScrewsFlashingStep 9.Attach th

Seite 16 - Figure 5.14

September 1, 2008Page 23Quadra-Fire · Castile Gas Stove · 7023-111E6Gas InformationA. Fuel ConversionsBefore making gas connections ensure that the

Seite 17 - Figure 5.16

Page 24September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111EFire Risk.Explosion Risk.• If the information in these instructions is not follow

Seite 18 - Figure 5.19

September 1, 2008Page 25Quadra-Fire · Castile Gas Stove · 7023-111EB. Gas PressuresIf the pressure is not sufﬁcient, ensure: 1) the piping used is la

Seite 19 - Figure 5.21

Page 26September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111E• A small amount of air will be in the gas supply lines. When ﬁrst lighting applia

Seite 20 - Figure 5.24

September 1, 2008Page 27Quadra-Fire · Castile Gas Stove · 7023-111E7Electrical InformationA. Recommendation for WireC. Standing Pilot Ignition Syst

Seite 21 - Figure 5.26

Page 28September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111EFigure 7.1CAUTIONLabel all wires prior to disconnection when servicing controls. W

Seite 22 - Figure 5.30

September 1, 2008Page 29Quadra-Fire · Castile Gas Stove · 7023-111E8Appliance SetupA. Remove Shipping MaterialsRemove shipping materials from inside

Seite 23 - Gas Information

Page 3Quadra-Fire · Castile Gas Stove · 7023-111E - TABLE OF CONTENTS - September 1, 2005Section 1: Listing and Code Approvals A. Appliance

Seite 24 - Diaphragm

Page 30September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111ED. Bafﬂe Installation/AdjustmentBAFFLE BAFFLE RETAINERS Figure 8.7 Position baf

Seite 25 - C. Gas Connection

September 1, 2008Page 31Quadra-Fire · Castile Gas Stove · 7023-111EF. Positioning the LogsWhile still breakable, the logs do not become fragile unti

Seite 26

Page 32September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111EHandle glass assembly with care.CAUTION• Inspect the gasket to ensure it is undam

Seite 27 - Electrical Information

September 1, 2008Page 33Quadra-Fire · Castile Gas Stove · 7023-111EFigure 8.19 Install speed control to switch panel. Attach knob to speed control

Seite 28 - Figure 7.1

Page 34September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111ESee vent graph for recommendations on page 11 before you begin your adjustment. I

Seite 29 - Appliance Setup

September 1, 2008Page 35Quadra-Fire · Castile Gas Stove · 7023-111E9Operating InstructionsA. Before Lighting ApplianceRead this entire manual prior

Seite 30 - E. Leg Leveling System

Page 36September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111EC. Lighting Appliance1. Set the thermostat to lowest setting. 2. Turn off all e

Seite 31 - H. Opening Front Door

September 1, 2008Page 37Quadra-Fire · Castile Gas Stove · 7023-111ED. After Appliance is LitWhen you light your appliance, you may notice that it pr

Seite 32 - J. Blower Installation

Page 38September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111E10TroubleshootingWith proper installation, operation, and maintenance your gas app

Seite 33 - 34 in. (864mm)

September 1, 2008Page 39Quadra-Fire · Castile Gas Stove · 7023-111ESymptom Possible Cause Corrective Action3. (Continued) c. Defective valve. Turn

Seite 34 - L. Shutter Adjustment

Page 4September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111E1Listing and Code ApprovalsThe product is listed to ANSI standards for “Vented Gas

Seite 35 - Operating Instructions

Page 40September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111E11Maintaining and Servicing Your ApplianceAlthough the frequency of your appliance

Seite 36 - TO TURN OFF GAS TO APPLIANCE

September 1, 2008Page 41Quadra-Fire · Castile Gas Stove · 7023-111EInspect Maintenance TasksDoors 1. Inspect for scratches, dents or other damage an

Seite 37 - ISSUE SOLUTIONS

Page 42September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111E12Reference MaterialsA. Appliance Dimension DiagramDimensions are actual appliance

Seite 38 - Troubleshooting

September 1, 2008Page 43Quadra-Fire · Castile Gas Stove · 7023-111EB. Vent Components DiagramFigure 12.2 SL-D Series Vent Components4 in. (102 mm)

Seite 39

Page 44September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111EC. Vent Components List DescriptionHHT SL-P M= Multi Pack (6)Simpson Dura-VentDire

Seite 40

September 1, 2008Page 45Quadra-Fire · Castile Gas Stove · 7023-111E45° Elbow, Swivel, Black - 46DVA-E45B - - SV4EB4590° Elbow, Galvanized SLP90M See

Seite 41 - A. Maintenance Tasks

Page 46September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111ED. Service Parts ListR CASTILE GAS(NG, LP) Exploded Parts DiagramBeginning

Seite 42 - Reference Materials

September 1, 2008Page 47Quadra-Fire · Castile Gas Stove · 7023-111EIMPORTANT: THIS IS DATED INFORMATION. The most current information is located on

Seite 43 - B. Vent Components Diagram

Page 48September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111ED. Service Parts List (cont’d.)R CASTILE GASBeginning Manufacturing Date:

Seite 44 - C. Vent Components List

September 1, 2008Page 49Quadra-Fire · Castile Gas Stove · 7023-111EIMPORTANT: THIS IS DATED INFORMATION. The most current information is located on

Seite 45 - Page 45

September 1, 2008Page 5Quadra-Fire · Castile Gas Stove · 7023-111ENOTE: The following requirements reference various Massachusetts and national codes

Seite 46 - CASTILE GAS

Page 50September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111EItem #DESCRIPTIONPART #14 Blower Assembly BK-GASConversion Kit, LP LPK-MBConversio

Seite 47

September 1, 2008Page 51Quadra-Fire · Castile Gas Stove · 7023-111EF. Service and Maintenance LogDate of Service Performed By Description of Service

Seite 48

Page 52September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111EG. Homeowner’s Notes

Seite 49

September 1, 2008Page 53Quadra-Fire · Castile Gas Stove · 7023-111EG. Homeowner’s Notes

Seite 50

Page 54September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111EH. Warranty PolicyHearth & Home Technologies LIMITED WARRANTYHearth & Hom

Seite 51 - Page 51

September 1, 2008Page 55Quadra-Fire · Castile Gas Stove · 7023-111E HHT’s obligation under this warranty does not extend to damages resulting from

Seite 52 - G. Homeowner’s Notes

Page 56Quadra-Fire · Castile Gas Stove · 7023-111E September 1, 2008Hearth & Home Technologies1445 North HighwayColville, WA 99114Division of HH

Seite 53

Page 6September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111E2Getting StartedCheck building codes prior to installation.• Installation MUST com

Seite 54 - 4021-645A 09-01-08

September 1, 2008Page 7Quadra-Fire · Castile Gas Stove · 7023-111E3Appliance Location and ClearancesA. Selecting Appliance LocationNOTE: · Illustrat

Seite 55

Page 8September 1, 2008Quadra-Fire · Castile Gas Stove · 7023-111E4Termination LocationsA. Vent Termination Minimum ClearancesFigure 4.2 Multiple V

Seite 56 - Your Records for Model:

September 1, 2008Page 9Quadra-Fire · Castile Gas Stove · 7023-111EFigure 4.4 V= VENT TERMINALX= AIR SUPPLY INLET = AREA WHERE TERMINAL IS NOT PERMI

Kommentare zu diesen Handbüchern

Keine Kommentare

Quadra-Fire Direct Room CASTILE-GAS-CWL Bedienungshandbuch

Stöbern Sie online oder laden Sie Bedienungshandbuch nach Kamine Quadra-Fire Direct Room CASTILE-GAS-CWL herunter. Quadra-Fire Direct Room CASTILE-GAS-CWL Owner`s manual Benutzerhandbuch

Inhaltsverzeichnis

Kommentare zu diesen Handbüchern

Verwandte Produkte und Handbücher für Kamine Quadra-Fire Direct Room CASTILE-GAS-CWL