Quadra-Fire Front Solitaire Front 839-1390 Bedienungsanleitung PDF herunterladen

Quartet Front

Solitaire Front

www.quadraﬁ re.com

January 28, 2008

250-7233F

ested and

Listed by

Beaverton

Oregon USA

OMNI- Test Laboratories, Inc.

DO NOT DISCARD THIS MANUAL

CAUTION

• Important operating and

maintenance instructions

included.

• Leave this manual with

party responsible for use

and operation.

• Read, understand and

follow these instructions

for safe installation and

operation.

• Do not store or use gasoline or other ﬂ am-

mable vapors and liquids in the vicinity of this

or any other appliance.

• What to do if you smell gas

- Do not try to light any appliance.

Do not touch any electrical switch. Do not

use any phone in your building.

- Immediately call your gas supplier from a

neighbor’s phone. Follow the gas supplier’s

instructions.

- If you cannot reach your gas supplier, call

the ﬁ re department.

• Installation and service must be performed

by a qualiﬁ ed installer, service agency, or the

gas supplier.

WARNING: If the information in these

instructions is not followed exactly, a ﬁ re

or explosion may result causing property

damage, personal injury, or death.

This appliance may be installed as an OEM installation in manufactured

home (USA only) or mobile home and must be installed in accordance with

the manufacturer's instructions and the manufactured home construction

and safety standard, Title 24 CFR, Part 3280 or Standard for Installation

in Mobile Homes, CAN/CSA Z240MH.

This appliance is only for use with the type(s) of gas indicated on the

rating plate.

Installation and service of this appliance should be

performed by qualiﬁ ed personnel. Hearth & Home

Technologies suggests NFI certiﬁ ed or factory-trained

professionals, or technicians super-

vised by an NFI certiﬁ ed professional.

WARNING

Glass and other surfaces are hot during oper-

ation and cool down.

• Keep children away.

• CAREFULLY SUPERVISE children in same

room as appliance.

HOT! DO NOT TOUCH.

SEVERE BURNS MAY RESULT.

CLOTHING IGNITION MAY RESULT.

• Alert children and adults to hazards of high temperatures.

• Do NOT operate with protective barriers open or removed.

• Keep clothing, furniture, draperies and other combustibles

away.

DO NOT

DISCARD

SAPPHIRE

DIRECT VENT ROOM HEATER

Owner’s Manual

Installation and Operation

Model:

839-1390

839-1440

839-1460

SAPPH-D-CSB

SAPPH-D-CWL

In the Commonwealth of Massachusetts:

• installation must be performed by a licensed plumber or gas

ﬁ tter.

See Table of Contents for additional Commonwealth of Mas-

sachusetts requirements.

1 2 3 4 5 6 ... 55 56

Inhaltsverzeichnis

Seite 1 - SAPPHIRE

Quartet FrontSolitaire Frontwww.quadraﬁ re.com January 28, 2008250-7233F RTested andListed byBeavertonOregon USAOMNI- Test Laboratories, Inc.CUSDO

Seite 2 - Test Lab & Report No

Page 10 January 28, 2008Quadra-Fire · Sapphire · 250-7233F5Vent InformationA. Venting ComponentsB. Use of ElbowsIn order to comply

Seite 3 - - TABLE OF CONTENTS

January 28, 2008Page 11Quadra-Fire · Sapphire · 250-7233ED. How to Use the Vent Graph E. Venting GuidelinesNOTE: IF YOUR INSTALLATION FALLS WITHIN

Seite 4 - ּCAN/CBA 2.17-M91

Page 12 January 28, 2008Quadra-Fire · Sapphire · 250-7233FFemale Locking LugsMale Locking LugsStep 1. Determine the desired locatio

Seite 5 - Massachusetts

January 28, 2008Page 13Quadra-Fire · Sapphire · 250-7233ENOTE:(1) Installation requires a minimum of 11 in. (279mm) horizontal run. Each 1 ft. (3

Seite 6 - Getting Started

Page 14 January 28, 2008Quadra-Fire · Sapphire · 250-7233FStep 5. Place the wall thimble cover over the pipe assembly and slide th

Seite 7 - B. Clearances

January 28, 2008Page 15Quadra-Fire · Sapphire · 250-7233EStep 1. Check the installation instructions for required 1 in. (25mm) clearances (air spa

Seite 8 - Termination Locations

Page 16 January 28, 2008Quadra-Fire · Sapphire · 250-7233FStep 4. Assemble the desired lengths of pipe and elbows necessary to reac

Seite 9 - Figure 4.4

January 28, 2008Page 17Quadra-Fire · Sapphire · 250-7233EMIN. 1 in. (25mm)CLEARANCECEILING FIRES TOPNAILSMIN. 1 in. (25mm)CLEARANCEMIN. 1 in. (25m

Seite 10 - Vent Information

Page 18 January 28, 2008Quadra-Fire · Sapphire · 250-7233F2. Cathedral CeilingLEVELCATHEDRAL CEILINGSUPPORT BOX2 in. (51mm)MIN. BEL

Seite 11 - Figure 5.2

January 28, 2008Page 19Quadra-Fire · Sapphire · 250-7233EHIGH WINDTERMINATIONCAPSHEET METALSCREWSDRILL FOUR 1/8 in.(3mm) DIAMETERHOLESFigure 5.21

Seite 12 - F. Horizontal Termination

Page 2Quadra-Fire · Sapphire · 250-7233F January 28, 2008Hearth & Home Technologies welcomes you to our tradition of excellence! In choosing

Seite 13 - Figure 5.5

Page 20 January 28, 2008Quadra-Fire · Sapphire · 250-7233F4. Existing Masonry ChimneyType A - Up & Out Installations for Top Ve

Seite 14 - Figure 5.7

January 28, 2008Page 21Quadra-Fire · Sapphire · 250-7233E10 in. x 10 in. (254mm x 254mm)FRAMED OPENING IN WALLSTUDWALLMASONRYCHIMNEYRETRO CONNECTO

Seite 15 - G. Vertical Termination

Page 22 January 28, 2008Quadra-Fire · Sapphire · 250-7233FHIGH WINDTERMINATIONCAPTOP ADAPTERTHREE SHEETMETAL SCREWSFLASHINGStep 9.A

Seite 16 - AND ROOFING NAILS

January 28, 2008Page 23Quadra-Fire · Sapphire · 250-7233E6Gas InformationA. Fuel ConversionsBefore making gas connections ensure that the applian

Seite 17 - Figure 5.16

Page 24 January 28, 2008Quadra-Fire · Sapphire · 250-7233FABCFigure 6.6 Turn control knob to the OFF position, ensure that gas su

Seite 18 - 2. Cathedral Ceiling

January 28, 2008Page 25Quadra-Fire · Sapphire · 250-7233EFire Risk.Explosion Risk.• If the information in these instructions is not followed exac

Seite 19 - 3. Class A Metal Chimney

Page 26 January 28, 2008Quadra-Fire · Sapphire · 250-7233F• A small amount of air will be in the gas supply lines. When ﬁ rst light

Seite 20 - 4. Existing Masonry Chimney

January 28, 2008Page 27Quadra-Fire · Sapphire · 250-7233E7Electrical InformationA. Recommendation for WireC. Standing Pilot Ignition System Wiri

Seite 21 - Figure 5.25

Page 28 January 28, 2008Quadra-Fire · Sapphire · 250-7233FFigure 7.1CAUTIONLabel all wires prior to disconnection when servicing co

Seite 22 - WALL THIMBLE COVER

January 28, 2008Page 29Quadra-Fire · Sapphire · 250-7233E8Appliance SetupA. Remove Shipping MaterialsRemove shipping materials from inside or und

Seite 23 - Gas Information

Page 3Quadra-Fire · Sapphire · 250-7233F- TABLE OF CONTENTS - January 28, 2008Section 1: Listing and Code Approvals A. Appliance Certiﬁ cations

Seite 24

Page 30 January 28, 2008Quadra-Fire · Sapphire · 250-7233FFigure 8.4 Install the inner ﬂ ue collar on rear of appliance, with damp

Seite 25 - B. Gas Pressures

January 28, 2008Page 31Quadra-Fire · Sapphire · 250-7233EFigure 8.9 Remove burner by sliding the shutter to the right, lifting up the left side o

Seite 26 - C. Gas Connection

Page 32 January 28, 2008Quadra-Fire · Sapphire · 250-7233FE. Front Installation Figure 8.13 To remove the face, loosen the thumb

Seite 27 - Electrical Information

January 28, 2008Page 33Quadra-Fire · Sapphire · 250-7233EF. Hearth Legs InstallationRefer to Section 12 for specific color part numbers.Hearth le

Seite 28 - THERMOCOUPLE

Page 34 January 28, 2008Quadra-Fire · Sapphire · 250-7233FH. Mineral Wool• Follow ember placement instructions in manual.• Do NO

Seite 29 - Appliance Setup

January 28, 2008Page 35Quadra-Fire · Sapphire · 250-7233ENOTE: This blower utilizes a snap disc to control ON and OFF operation. When the correct

Seite 30

Page 36 January 28, 2008Quadra-Fire · Sapphire · 250-7233FSNAPDISC6 in. (152mm) BLACKBLOWER4 in. (102mm) WHITECORDMFMF34 in. (864mm

Seite 31 - D. Accessories

January 28, 2008Page 37Quadra-Fire · Sapphire · 250-7233ESee vent graph for recommendations on page 11 before you begin your adjustment. If your

Seite 32 - E. Front Installation

Page 38 January 28, 2008Quadra-Fire · Sapphire · 250-7233F9Operating InstructionsA. Before Lighting ApplianceRead this entire manu

Seite 33 - G. Positioning the Logs

January 28, 2008Page 39Quadra-Fire · Sapphire · 250-7233EC. Lighting Appliance1. Set the thermostat to lowest setting. 2. Turn off all electric

Seite 34 - J. Blower Installation

Page 4 January 28, 2008Quadra-Fire · Sapphire · 250-7233F1Listing and Code ApprovalsThe product is listed to ANSI standards for “Ve

Seite 35

Page 40 January 28, 2008Quadra-Fire · Sapphire · 250-7233FD. After Appliance is LitWhen you light your appliance, you may notice t

Seite 36 - Page 36

January 28, 2008Page 41Quadra-Fire · Sapphire · 250-7233E10TroubleshootingWith proper installation, operation, and maintenance your gas appliance

Seite 37 - Rear Access Plate

Page 42 January 28, 2008Quadra-Fire · Sapphire · 250-7233FSymptom Possible Cause Corrective Action3. (Continued) c. Defective val

Seite 38 - Operating Instructions

January 28, 2008Page 43Quadra-Fire · Sapphire · 250-7233E11Maintaining and Servicing ApplianceAlthough the frequency of your appliance servicing a

Seite 39 - Page 39

Page 44 January 28, 2008Quadra-Fire · Sapphire · 250-7233FInspect Maintenance TasksDoors 1. Inspect for scratches, dents or other

Seite 40 - ISSUE SOLUTIONS

January 28, 2008Page 45Quadra-Fire · Sapphire · 250-7233EB. Service and Maintenance LogDate of Service Performed By Description of Service

Seite 41 - Troubleshooting

Page 46 January 28, 2008Quadra-Fire · Sapphire · 250-7233F12Reference MaterialsA. Appliance Dimension DiagramDimensions are actual

Seite 42

January 28, 2008Page 47Quadra-Fire · Sapphire · 250-7233EB. Vent Components DiagramFigure 12.2 SL-D Series Vent Components4 in. (102 mm) inner

Seite 43

Page 48 January 28, 2008Quadra-Fire · Sapphire · 250-7233FC. Vent Components List COMPONENTS930D Ceiling Support / Wall Thimble, Bl

Seite 44 - A Maintenance Tasks

January 28, 2008Page 49Quadra-Fire · Sapphire · 250-7233ED. Service Parts ListR SAPPHIRE(NG, LP) Exploded Parts DiagramBeginning Manuf

Seite 45 - Page 45

January 28, 2008Page 5Quadra-Fire · Sapphire · 250-7233ENOTE: The following requirements reference various Massachusetts and national codes not co

Seite 46 - Reference Materials

Page 50 January 28, 2008Quadra-Fire · Sapphire · 250-7233FItem #Part DescriptionAlphabetical OrderSKUAdapter, DV 7000-16218 Adapter

Seite 47 - B. Vent Components Diagram

January 28, 2008Page 51Quadra-Fire · Sapphire · 250-7233EItem #Part DescriptionAlphabetical OrderSKUIMPORTANT: THIS IS DATED INFORMATION. The mos

Seite 48 - TERMINATION KITS

Page 52 January 28, 2008Quadra-Fire · Sapphire · 250-7233FIMPORTANT: THIS IS DATED INFORMATION. The most current information is lo

Seite 49

January 28, 2008Page 53Quadra-Fire · Sapphire · 250-7233EF. Warranty PolicyLifetime WarrantyRLIMITED LIFETIME WARRANTYThe Hearth & Home Techn

Seite 50

Page 54 January 28, 2008Quadra-Fire · Sapphire · 250-7233FTHIS PAGE INTENTIONALLY LEFT BLANK.

Seite 51 - Service Parts (cont’d.)

January 28, 2008Page 55Quadra-Fire · Sapphire · 250-7233ETHIS PAGE INTENTIONALLY LEFT BLANK.

Seite 52

Page 56Quadra-Fire · Sapphire · 250-7233F January 28, 2008 Hearth & Home Technologies1445 North HighwayColville, WA 99114Division of HHT INDU

Seite 53 - Lifetime Warranty

Page 6 January 28, 2008Quadra-Fire · Sapphire · 250-7233F2Getting StartedCheck building codes prior to installation.• Installation

Seite 54 - LEFT BLANK

January 28, 2008Page 7Quadra-Fire · Sapphire · 250-7233E3Appliance Location and ClearancesA. Selecting Appliance LocationNOTE: · Illustrations re

Seite 55

Page 8 January 28, 2008Quadra-Fire · Sapphire · 250-7233F4Termination LocationsA. Vent Termination Minimum Clearances24 in. (610mm)

Seite 56 - Your Records for Model:

January 28, 2008Page 9Quadra-Fire · Sapphire · 250-7233EFigure 4.4 V= VENT TERMINALX= AIR SUPPLY INLET = AREA WHERE TERMINAL IS NOT PERMITTEDA =

Kommentare zu diesen Handbüchern

Keine Kommentare

Quadra-Fire Front Solitaire Front 839-1390 Bedienungsanleitung

Stöbern Sie online oder laden Sie Bedienungsanleitung nach Kamine Quadra-Fire Front Solitaire Front 839-1390 herunter. Quadra-Fire Front Solitaire Front 839-1390 User's Manual Benutzerhandbuch

Inhaltsverzeichnis

Kommentare zu diesen Handbüchern

Verwandte Produkte und Handbücher für Kamine Quadra-Fire Front Solitaire Front 839-1390