Quadra-Fire Direct Vent Room Heater 839-1440 Bedienungshandbuch PDF herunterladen

Quartet Front

Solitaire Front

www.quadraﬁre.com

September 1, 2008

250-7233H

O-T L

Tested and

Listed by

Portland

Oregon USA

OMNI-Test Laboratories, Inc.

DO NOT DISCARD THIS MANUAL

CAUTION

• Important operating and

maintenance instructions

included.

• Leave this manual with

party responsible for use

and operation.

• Read, understand and

follow these instructions

for safe installation and

operation.

• Do not store or use gasoline or other ﬂam-

mable vapors and liquids in the vicinity of this

or any other appliance.

• What to do if you smell gas

- Do not try to light any appliance.

Do not touch any electrical switch. Do not

use any phone in your building.

- Immediately call your gas supplier from a

neighbor’s phone. Follow the gas supplier’s

instructions.

- If you cannot reach your gas supplier, call

the ﬁre department.

• Installation and service must be performed

by a qualiﬁed installer, service agency, or the

gas supplier.

WARNING: If the information in these

instructions is not followed exactly, a ﬁre

or explosion may result causing property

damage, personal injury, or death.

Installation and service of this appliance should be

performed by qualiﬁed personnel. Hearth & Home

Technologies suggests NFI certiﬁed or factory-trained

professionals, or technicians supervised by an NFI

certiﬁed professional.

DO NOT

DISCARD

SAPPHIRE

DIRECT VENT ROOM HEATER

Owner’s Manual

Installation and Operation

Model:

839-1390

839-1440

839-1460

SAPPH-D-CSB

SAPPH-D-CWL

This appliance may be installed as an OEM installation in manufactured home (USA

only) or mobile home and must be installed in accordance with the manufacturer's

instructions and the manufactured home construction and safety standard, Title 24

CFR, Part 3280 or Standard for Installation in Mobile Homes, CAN/CSA Z240MH.

This appliance is only for use with the type(s) of gas indicated on the rating plate.

In the Commonwealth of Massachusetts:

• installation must be performed by a licensed plumber or gas

ﬁtter.

See Table of Contents for additional Commonwealth of Mas-

sachusetts requirements.

HOT SURFACES!

Glass and other surfaces are

hot during operation AND

cool down.

Hot glass will cause

burns.

WARNING

• Do not touch glass until it is cooled

• NEVER allow children to touch glass

• Keep children away

• CAREFULLY SUPERVISE children in the same room as

appliance

• Alert children and adults to hazards of high temperatures

High temperatures may ignite clothing or other

ﬂammable materials.

• Keep clothing, furniture, draperies and other combustibles

away.

1 2 3 4 5 6 ... 55 56

Inhaltsverzeichnis

Seite 1 - SAPPHIRE

Quartet FrontSolitaire Frontwww.quadraﬁre.com September 1, 2008250-7233H R O-T LTested and Listed byPortlandOregon USAOMNI-Test Laboratories, Inc.CUS

Seite 2 - Test Lab & Report No

Page 10 September 1, 2008Quadra-Fire · Sapphire · 250-7233H5Vent InformationA. Venting ComponentsB. Use of ElbowsIn order to comply w

Seite 3 - - TABLE OF CONTENTS

September 1, 2008Page 11Quadra-Fire · Sapphire · 250-7233HD. How to Use the Vent Graph E. Venting GuidelinesNOTE: IF YOUR INSTALLATION FALLS

Seite 4 - ּCAN/CBA 2.17-M91

Page 12 September 1, 2008Quadra-Fire · Sapphire · 250-7233HFemale Locking LugsMale Locking LugsStep 1. Determine the desired location

Seite 5 - Massachusetts

September 1, 2008Page 13Quadra-Fire · Sapphire · 250-7233HNOTE:(1) Installation requires a minimum of 11 in. (279mm) horizontal run. Each 1

Seite 6 - Getting Started

Page 14 September 1, 2008Quadra-Fire · Sapphire · 250-7233HStep 5. Place the wall thimble cover over the pipe assembly and slide the

Seite 7 - B. Clearances

September 1, 2008Page 15Quadra-Fire · Sapphire · 250-7233HStep 1. Check the installation instructions for required 1 in. (25mm) clearances (

Seite 8 - Termination Locations

Page 16 September 1, 2008Quadra-Fire · Sapphire · 250-7233HStep 4. Assemble the desired lengths of pipe and elbows necessary to reach

Seite 9 - Alcove Applications

September 1, 2008Page 17Quadra-Fire · Sapphire · 250-7233HCeiling FirestopNailsMinimum 1 in. (24mm) ClearanceMinimum 1 in. (24mm) ClearanceM

Seite 10 - Vent Information

Page 18 September 1, 2008Quadra-Fire · Sapphire · 250-7233H2. Cathedral CeilingLevelCathedral Ceiling Support Box2 in. (51mm) Min. be

Seite 11 - Figure 5.2

September 1, 2008Page 19Quadra-Fire · Sapphire · 250-7233HHigh Wind Termination CapSheet Metal ScrewsDrill Four 1/8 in. (3mm) Diamater Holes

Seite 12 - F. Horizontal Termination

Page 2Quadra-Fire · Sapphire · 250-7233H September 1, 2008and Welcome to the Quadra-Fire Family!Hearth & Home Technologies welcomes you to our

Seite 13 - Rear Vent Kit

Page 20 September 1, 2008Quadra-Fire · Sapphire · 250-7233H4. Existing Masonry ChimneyType A - Up & Out Installations for Top Ven

Seite 14 - Figure 5.7

September 1, 2008Page 21Quadra-Fire · Sapphire · 250-7233H10 in. x 10 in. (254mm x 254mm) framed opening in wallStudwallMasonry ChimneyRetro

Seite 15 - G. Vertical Termination

Page 22 September 1, 2008Quadra-Fire · Sapphire · 250-7233HHigh Wind Termination CapTop Adaptor(3) Sheet Metal ScrewsFlashingStep 9.A

Seite 16 - Figure 5.15

September 1, 2008Page 23Quadra-Fire · Sapphire · 250-7233H6Gas InformationA. Fuel ConversionsBefore making gas connections ensure that the

Seite 17 - Figure 5.16

Page 24 September 1, 2008Quadra-Fire · Sapphire · 250-7233HA B C Mounting ScrewsPressure Regulator TowerDiaphragmFigure 6.6 Turn co

Seite 18 - Figure 5.18

September 1, 2008Page 25Quadra-Fire · Sapphire · 250-7233HFire Risk.Explosion Risk.• If the information in these instructions is not follow

Seite 19 - 3. Class A Metal Chimney

Page 26 September 1, 2008Quadra-Fire · Sapphire · 250-7233H• A small amount of air will be in the gas supply lines. When ﬁrst lightin

Seite 20 - 4. Existing Masonry Chimney

September 1, 2008Page 27Quadra-Fire · Sapphire · 250-7233H7Electrical InformationA. Recommendation for WireC. Standing Pilot Ignition Syst

Seite 21 - Figure 5.25

Page 28 September 1, 2008Quadra-Fire · Sapphire · 250-7233HFigure 7.1CAUTIONLabel all wires prior to disconnection when servicing con

Seite 22 - Figure 5.29

September 1, 2008Page 29Quadra-Fire · Sapphire · 250-7233H8Appliance SetupA. Remove Shipping MaterialsRemove shipping materials from inside

Seite 23 - Gas Information

Page 3Quadra-Fire · Sapphire · 250-7233H- TABLE OF CONTENTS - September 1, 2008Section 1: Listing and Code Approvals A. Appliance Certiﬁcatio

Seite 24 - Diaphragm

Page 30 September 1, 2008Quadra-Fire · Sapphire · 250-7233HFigure 8.4 Install the inner ﬂue collar on rear of appliance, with damper

Seite 25 - Identification Label

September 1, 2008Page 31Quadra-Fire · Sapphire · 250-7233HFigure 8.9 Remove burner by sliding the shutter to the right, lifting up the left

Seite 26 - C. Gas Connection

Page 32 September 1, 2008Quadra-Fire · Sapphire · 250-7233HE. Front Installation Figure 8.13 To remove the face, loosen the thumb

Seite 27 - Electrical Information

September 1, 2008Page 33Quadra-Fire · Sapphire · 250-7233HF. Hearth Legs InstallationRefer to Section 12 for specific color part numbers.He

Seite 28 - Thermocouple

Page 34 September 1, 2008Quadra-Fire · Sapphire · 250-7233HH. Mineral Wool• Follow ember placement instructions in manual.• Do NOT

Seite 29 - Appliance Setup

September 1, 2008Page 35Quadra-Fire · Sapphire · 250-7233HNOTE: This blower utilizes a snap disc to control ON and OFF operation. When the

Seite 30 - Burner Locator

Page 36 September 1, 2008Quadra-Fire · Sapphire · 250-7233HSNAP DISC 6 in. (152mm) BLACK BLOWER 4 in. (102mm) WHITE CORD M F M F 34 i

Seite 31 - D. Accessories

September 1, 2008Page 37Quadra-Fire · Sapphire · 250-7233HSee vent graph for recommendations on page 11 before you begin your adjustment. I

Seite 32 - E. Front Installation

Page 38 September 1, 2008Quadra-Fire · Sapphire · 250-7233H9Operating InstructionsA. Before Lighting ApplianceRead this entire manua

Seite 33

September 1, 2008Page 39Quadra-Fire · Sapphire · 250-7233HC. Lighting Appliance1. Set the thermostat to lowest setting. 2. Turn off all e

Seite 34 - J. Blower Installation

Page 4 September 1, 2008Quadra-Fire · Sapphire · 250-7233H1Listing and Code ApprovalsThe product is listed to ANSI standards for “Ven

Seite 35

Page 40 September 1, 2008Quadra-Fire · Sapphire · 250-7233HD. After Appliance is LitWhen you light your appliance, you may notice th

Seite 36 - Page 36

September 1, 2008Page 41Quadra-Fire · Sapphire · 250-7233H10TroubleshootingWith proper installation, operation, and maintenance your gas app

Seite 37 - Rear Access Plate

Page 42 September 1, 2008Quadra-Fire · Sapphire · 250-7233HSymptom Possible Cause Corrective Action3. (Continued) c. Defective valv

Seite 38 - Operating Instructions

September 1, 2008Page 43Quadra-Fire · Sapphire · 250-7233H11Maintaining and Servicing ApplianceAlthough the frequency of your appliance serv

Seite 39 - TO TURN OFF GAS TO APPLIANCE

Page 44 September 1, 2008Quadra-Fire · Sapphire · 250-7233HInspect Maintenance TasksDoors 1. Inspect for scratches, dents or other d

Seite 40 - ISSUE SOLUTIONS

September 1, 2008Page 45Quadra-Fire · Sapphire · 250-7233H12Reference MaterialsA. Appliance Dimension DiagramDimensions are actual appliance

Seite 41 - Troubleshooting

Page 46 September 1, 2008Quadra-Fire · Sapphire · 250-7233HB. Vent Components DiagramFigure 12.2 SL-D Series Vent Components4 in.

Seite 42

September 1, 2008Page 47Quadra-Fire · Sapphire · 250-7233HC. Vent Components List DescriptionHHT SL-P M= Multi Pack (6)Simpson Dura-VentDire

Seite 43

Page 48 September 1, 2008Quadra-Fire · Sapphire · 250-7233H45° Elbow, Swivel, Black - 46DVA-E45B - - SV4EB4590° Elbow, Galvanized SLP

Seite 44 - A Maintenance Tasks

September 1, 2008Page 49Quadra-Fire · Sapphire · 250-7233HD. Service Parts ListR SAPPHIRE(NG, LP) Exploded Parts DiagramBeginni

Seite 45 - Reference Materials

September 1, 2008Page 5Quadra-Fire · Sapphire · 250-7233HNOTE: The following requirements reference various Massachusetts and national codes

Seite 46 - B. Vent Components Diagram

Page 50 September 1, 2008Quadra-Fire · Sapphire · 250-7233HItem #Part DescriptionAlphabetical OrderSKUAdapter, DV 7000-16218 Adapter,

Seite 47 - C. Vent Components List

September 1, 2008Page 51Quadra-Fire · Sapphire · 250-7233HItem #Part DescriptionAlphabetical OrderSKUIMPORTANT: THIS IS DATED INFORMATION.

Seite 48 - - 46DVA-ES 4DT-OS - SV4SU

Page 52 September 1, 2008Quadra-Fire · Sapphire · 250-7233HIMPORTANT: THIS IS DATED INFORMATION. The most current information is loc

Seite 49

September 1, 2008Page 53Quadra-Fire · Sapphire · 250-7233HF. Service and Maintenance LogDate of Service Performed By Description of Service

Seite 50

Page 54 September 1, 2008Quadra-Fire · Sapphire · 250-7233HG. Warranty PolicyHearth & Home Technologies LIMITED WARRANTYHearth &

Seite 51 - Service Parts (cont’d.)

September 1, 2008Page 55Quadra-Fire · Sapphire · 250-7233H HHT’s obligation under this warranty does not extend to damages resulting from

Seite 52

Page 56Quadra-Fire · Sapphire · 250-7233H September 1, 2008Hearth & Home Technologies1445 North HighwayColville, WA 99114Division of HHT INDUSTR

Seite 53 - Page 53

Page 6 September 1, 2008Quadra-Fire · Sapphire · 250-7233H2Getting StartedCheck building codes prior to installation.• Installation

Seite 54 - G. Warranty Policy

September 1, 2008Page 7Quadra-Fire · Sapphire · 250-7233H3Appliance Location and ClearancesA. Selecting Appliance LocationNOTE: · Illustrat

Seite 55 - 4021-645A 09-01-08

Page 8 September 1, 2008Quadra-Fire · Sapphire · 250-7233H4Termination LocationsA. Vent Termination Minimum Clearances20 in. (508mm)

Seite 56 - Your Records for Model:

September 1, 2008Page 9Quadra-Fire · Sapphire · 250-7233HFigure 4.4 V= VENT TERMINALX= AIR SUPPLY INLET = AREA WHERE TERMINAL IS NOT PERMI

Kommentare zu diesen Handbüchern

Keine Kommentare

Quadra-Fire Direct Vent Room Heater 839-1440 Bedienungshandbuch

Stöbern Sie online oder laden Sie Bedienungshandbuch nach Kamine Quadra-Fire Direct Vent Room Heater 839-1440 herunter. Quadra-Fire Direct Vent Room Heater 839-1440 Owner`s manual Benutzerhandbuch

Inhaltsverzeichnis

Kommentare zu diesen Handbüchern

Verwandte Produkte und Handbücher für Kamine Quadra-Fire Direct Vent Room Heater 839-1440